Possible Tranny Trouble - Shifting Issues

mrdueck
Posts: 151
Joined: Sat Dec 05, 2009 5:55 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: '95 L400 Super Exceed LWB
Location: Winnipeg
Location: Winnipeg, MB

Re: Possible Tranny Trouble - Shifting Issues

Post by mrdueck »

My TPS is turned to the max. It goes OK but the voltage is almost 1. Profister, how much is a new TPS?
User avatar
tonydca
Posts: 646
Joined: Tue May 19, 2009 9:01 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 95 L400 Exceed - yeah, baby!
Location: Vancouver BC
Location: Vancouver BC

Re: Possible Tranny Trouble - Shifting Issues

Post by tonydca »

jfarsang wrote:At least you saved yourself a cool $4k in a tranny rebuild had you taken it to a shop that said 'that's the problem right there'.
ZZzzzinggg! :o 8-)
Cry "Havoc!" and let slip the elementary-school-aged boys...
User avatar
CREGAN
Posts: 1094
Joined: Thu Sep 24, 2009 8:05 am
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 94 L400 SpaceGear Super Exceed
Location: Leduc, Alberta

Re: Possible Tranny Trouble - Shifting Issues

Post by CREGAN »

Well, I got 2 days out of it. Driving 25km to and back from Edmonton and it is back to Ferret Fighting. I think this may be a sign I need a new TPS. Agreed? Going outside to try and see how much it has slipped in either direction because I know for a fact it was set to 0.79 two days ago.

Edit: OK now when I hook up the voltmeter I get a clicking noise at the blue/yellow wire and no reading. Starting to get a little frustrated.


Craig
User avatar
jessef
Posts: 6458
Joined: Tue Feb 26, 2008 1:27 pm
Vehicle: JDM flavour of the month
Location: Vancouver
Location: Vancouver, BC

Re: Possible Tranny Trouble - Shifting Issues

Post by jessef »

Try cleaning the connector plugs and put a bit of dielectric grease on it. If that doesn't work then new TPS
User avatar
tonydca
Posts: 646
Joined: Tue May 19, 2009 9:01 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 95 L400 Exceed - yeah, baby!
Location: Vancouver BC
Location: Vancouver BC

Re: Possible Tranny Trouble - Shifting Issues

Post by tonydca »

Also try loosening the screw(s?) which allow you to rotate/adjust it, then give it a few back-and-forths for the full extent of its travel before re-measuring/adjusting the voltage and tightening it back up.

Sometimes dirt or other crud can accumulate inside electronic bits, and in the event it's hardly been moved in the past 15 years or so, a bit of a shakeup might just do the trick.

Worth a try before replacing....
Cry "Havoc!" and let slip the elementary-school-aged boys...
User avatar
CREGAN
Posts: 1094
Joined: Thu Sep 24, 2009 8:05 am
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 94 L400 SpaceGear Super Exceed
Location: Leduc, Alberta

Re: Possible Tranny Trouble - Shifting Issues

Post by CREGAN »

tonydca wrote:Also try loosening the screw(s?) which allow you to rotate/adjust it, then give it a few back-and-forths for the full extent of its travel before re-measuring/adjusting the voltage and tightening it back up.

Sometimes dirt or other crud can accumulate inside electronic bits, and in the event it's hardly been moved in the past 15 years or so, a bit of a shakeup might just do the trick.

Worth a try before replacing....
I will give it a try, but I am not measuring even a reading and when I connect the red probe to the blue/yellow wire, the TPS just clicks. Will try this afternoon. I think it has been screwed for a while. I have had the crappy shifting issue for months. I think the adjustment was probably what pushed it over the edge.

Craig
User avatar
CREGAN
Posts: 1094
Joined: Thu Sep 24, 2009 8:05 am
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 94 L400 SpaceGear Super Exceed
Location: Leduc, Alberta

Re: Possible Tranny Trouble - Shifting Issues

Post by CREGAN »

OK well I couldn't wait until this afternoon. I still get nothing after trying the last two tips. Zero voltage on both wires. I guess I need a new TPS. Hopefully I can get one soon, because driving it while working normally was really kind of fun!

Craig
User avatar
MardyDelica
Posts: 2190
Joined: Sun Jan 14, 2007 3:32 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: DL#30843 /92 Delica Super Exceed
Location: Richmond B.C.
Contact:

Re: Possible Tranny Trouble - Shifting Issues

Post by MardyDelica »

hi, craig, you need a tps sensor.
if its in this case.
check again if you do it right sometime we did hock up in the wrong wire and then there is no reading .
check again pls.
do it slow step by step pls
Cheers;
ImageImageImage
User avatar
CREGAN
Posts: 1094
Joined: Thu Sep 24, 2009 8:05 am
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 94 L400 SpaceGear Super Exceed
Location: Leduc, Alberta

Re: Possible Tranny Trouble - Shifting Issues

Post by CREGAN »

MardyDelica wrote:hi, craig, you need a tps sensor.
if its in this case.
check again if you do it right sometime we did hock up in the wrong wire and then there is no reading .
check again pls.
do it slow step by step pls
Cheers;
Hey Mardy - I have done it four times now since last night and still the same result. I never unhooked any wires or anything other than the 2 to the intercooler. I will check it one more time.

Craig
User avatar
MardyDelica
Posts: 2190
Joined: Sun Jan 14, 2007 3:32 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: DL#30843 /92 Delica Super Exceed
Location: Richmond B.C.
Contact:

Re: Possible Tranny Trouble - Shifting Issues

Post by MardyDelica »

hi, craig,
ok pls phone me
thank you
Mardy
ImageImageImage
User avatar
Profister
Posts: 963
Joined: Fri Feb 08, 2008 3:41 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: 1999 PE8W Chamonix, EFI
Location: North Vancouver, BC

Re: Possible Tranny Trouble - Shifting Issues

Post by Profister »

mrdueck wrote:My TPS is turned to the max. It goes OK but the voltage is almost 1. Profister, how much is a new TPS?
Sorry for the delay; I was away camping. I am not sure about the cost because that was a part of pre-sales service at Amazing Auto Imports and Mardy mentioned my name already. According to Google the part MD620874 price is bouncing at around $200.
Image
User avatar
thedjjack
Posts: 2025
Joined: Wed Jan 27, 2010 12:13 am
Member's Photo Album: http://www.delica.ca/forum/ucp.php?i=164
Vehicle: 1989 L300 HITOP!!
Location: Port McNeill
Location: Port McNeill
Contact:

Re: Possible Tranny Trouble - Shifting Issues

Post by thedjjack »

1st generation Dodge trucks with the 12V Cummins have a problem TPS as well....The solution on the Dodges is to wire in a volume control on the dash. You can set the resistance and gives you nice on the fly adjustment of the shift points.

We did this on a friends Cummins and it works awesome...total cost is 12.00 and maybe a good solution.

Just an idea $12.00 is better then $200.00 and I cannot tell you how nice the adjustable shift points are towing, driving, hills etc..

Here is the link:
http://www.dieseltruckresource.com/dev/ ... l?t=142641
oceanchem
Posts: 28
Joined: Mon Oct 17, 2011 12:01 pm
Member's Photo Album: http://www.delica.ca/Photos/
Vehicle: Mitsubishi L400 Spacegear 1996
Location: Saanich

Possible Tranny Trouble - Shifting Issues

Post by oceanchem »

I know this is way down thread but this information saved me as well. Was told I needed a transmission inspection and likely rebuild. Found this, moved my intercooler out of the way and then found the voltage on my TPS to be 0.62 V. Adjusted to 0.8 V and my problems disappeared for now. Thank you.
ImageImage
Locked

Return to “Drive Train”